Announcement

Collapse
No announcement yet.

2000 Yamaha Road Star Engine Oil Leak

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

  • 2000 Yamaha Road Star Engine Oil Leak

    Take deep close at the picture, my 2000 Yamaha Road Star is leaking oil. Am hoping there's no cracks on the bottom base as you can see that's it oil wet, but the main leakage is around the bolt. Any ideas would be appreciated. Thank you for your honest answers

  • #2
    Oil drain plug. The crushed washer needs to be replace and torque to spec. You can reuse them but I don’t. Cheap insurance is to replace it and be done with it.

    Comment


    • Purplestar
      Purplestar commented
      Editing a comment
      Bought two 17mm drain bolts and 10 14mm drain washers from Amazon, on my near oil change will replace, thank you.

  • #3
    The original silver crush washers are more than likely still on the drain plugs BUT they have been reused and never replaced and finally are so thin they don't seal against metal surface. Have to dig them off bolt with a sharp edge of a thin knife to remove. Order a pack or 14mm copper crush washers and replace both each oil change
    LET'S RIDE

    Comment


    • Purplestar
      Purplestar commented
      Editing a comment
      Bought two 17mm drain bolts and 10 14mm drain washers from Amazon, on my near oil change will replace, thank you.

  • #4
    After changing the oil, bolt and crush washer and replacing it for a new one, it still leaking,,

    Comment


    • #5
      Originally posted by Purplestar View Post
      After changing the oil, bolt and crush washer and replacing it for a new one, it still leaking,,
      Leaking from same spot...the drain plug? Clean both drain bolt areas real good with paper towel and brake clean. Did you tighten enough (manual has torque value..don't over tighten and crack housing!).

      Did you notice it leaking before changing oil.

      Pic of crush washer you used ?
      LET'S RIDE

      Comment


      • #6
        I have found that the only washers that seal are the OEM ones which are a thin hollow metal, likely aluminum. I have tried steel automotive washers that look the same but they don't seal. The rubber ones you get at the auto store definitely don't work. Your washers should be hollow and crush slightly as you tighten them down. Don't get them confused with the brass or aluminum type washers that are used on brake lines.

        Comment


        • #7
          I've used the copper crush washers on probably 20 bikes (but 20 pack or 50pack at a time in Amazon cheap) and they always work well. Not worth reusing for about 3 cents each just get new ones.

          One thing is to make sure you have removed the original one that may be smahed up real thing...use a thin blade pocket knife to get it off the bolt...if you don't look close it may appear there isn't one....

          If you double up a good copper washer and an old mashed aluminum one that MIGHT leak
          LET'S RIDE

          Comment


          • #8
            I have found these seals to work really well.
            Dowty seal bonded washer. M14. Pack of 8. Water, Oil,Fuel Resistant Top Quality. You can use 9/16" ones as well.
            https://www.ebay.com/itm/22433632895...kAAOSwo1lcUG~S

            Comment


          • #9
            This is what I used. I was going to put on the aluminum crush washers but thought maybe the rubber washer would seal better.
            Attached Files

            Comment


            • DEEPHATE
              DEEPHATE commented
              Editing a comment
              I used something similar on the oil tank plug but not on the engine plug. The OE ones actually "crush" as you tighten them where this style doesn't.

          • #10
            Previously it had the OEM crush washer and it was still leaking from the engine plug.
            Attached Files

            Comment


            • #11
              Hopefully the bolt wasn't overtightened and damaged/cracked anything...which would be pretty unusual
              LET'S RIDE

              Comment


              • roadiemort
                roadiemort commented
                Editing a comment
                Rare but it does happen. Darrel Edway (RIP) broke a chunk off his 04's case removing the oil drain plug.

            Latest Posts

            Collapse

            Topics Statistics Last Post
            Started by Mad Maj, 9 hours ago
            7 responses
            50 views
            0 likes
            Last Post Tcontrol  
            Started by Sykobox, 7 hours ago
            7 responses
            46 views
            0 likes
            Last Post Lug Nut
            by Lug Nut
             
            Started by KFallsRider, 9 hours ago
            6 responses
            34 views
            0 likes
            Last Post Father Pobasturd  
            Started by 6door7r, 13 hours ago
            9 responses
            46 views
            0 likes
            Last Post 6door7r
            by 6door7r
             
            Started by roadiemort, 2 days ago
            5 responses
            25 views
            0 likes
            Last Post roadiemort  
            Started by roadiemort, 8 hours ago
            0 responses
            19 views
            0 likes
            Last Post roadiemort  
            Started by Kmartcivic, 18 hours ago
            3 responses
            52 views
            0 likes
            Last Post Engineman  
            Started by Mad Maj, 2 weeks ago
            14 responses
            182 views
            0 likes
            Last Post Mad Maj
            by Mad Maj
             
            Started by brianmac, 21 hours ago
            1 response
            45 views
            0 likes
            Last Post Shotround  
            Started by Bnag0, 04-13-2022, 11:05 PM
            103 responses
            1,301 views
            1 like
            Last Post Bnag0
            by Bnag0
             
            Started by 6door7r, 4 days ago
            5 responses
            116 views
            3 likes
            Last Post Chromepony  
            Started by Lug Nut, 1 day ago
            3 responses
            60 views
            0 likes
            Last Post Lug Nut
            by Lug Nut
             
            Started by Tykes_Place, 3 weeks ago
            27 responses
            323 views
            0 likes
            Last Post Lug Nut
            by Lug Nut
             
            Started by p birk, 5 days ago
            16 responses
            164 views
            0 likes
            Last Post Tcontrol  
            Started by V-Max, 03-05-2018, 09:08 AM
            57 responses
            4,864 views
            0 likes
            Last Post Shotround  
            Started by luff_tackle, 2 days ago
            9 responses
            126 views
            0 likes
            Last Post brianmac  
            Started by jb3472, 3 days ago
            14 responses
            98 views
            0 likes
            Last Post Chooch
            by Chooch
             
            Started by ABCarr, 5 days ago
            14 responses
            169 views
            0 likes
            Last Post ABCarr
            by ABCarr
             
            Started by BloodMoney, 04-15-2022, 02:28 PM
            17 responses
            180 views
            0 likes
            Last Post BloodMoney  
            Started by Lug Nut, 4 days ago
            11 responses
            104 views
            2 likes
            Last Post Lug Nut
            by Lug Nut
             
            Working...
            X