Announcement

Collapse
No announcement yet.

no throttle response at all

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

  • no throttle response at all

    2001 Roadstar Silverado., Long shot exhaust, KN air filter on stock air box.

    Set for 2 years. Bought on Craigslist. 6.5 quarts of diesel smelling oil, same for gas int tank, which was black fuel.gasoline. Including tank.
    CV carb severely cleaned and all new parts,jets,diaphragms,needle and seat. Removed AIS, that stopped backfire into carb and pipes.
    Plugged heads. Lot of carbon when AIS removed. Spark plugs totally carboned. Replaced.. Great spark.
    Adjusted PMS for 5500 altitude. Pulled on enrichener, will run to 10,000 feet, runs rich of course, coked up exhuast.
    Take off enrichener of one notch. Will idle smooth, but zero throttle response, slide diaphragm new,etc.

    I this a symptom of SVS? Stuck valves. Has new fuel pump, petcock flows freely with volume. New fuel filter.
    New TPS, old one shot, I think it was used part.

    Any help here before winter sets in?

  • #2
    I can put a micro cloth or similiar over intake half covered, and it will run to the limiter.
    has 11,000 miles on it.

    Comment


    • #3
      the venturi slide never moves, and the rear cyclinder vent tube plugged into the cv port makes no difference in the lack of movement, unplugged either.
      are there two vacuum ports for the slide?

      Comment


      • #4
        float set to Jeff "the mucker" advice. I have the service manual on pdf.

        Comment


        • #5
          any help Please?
          Would like to ride this thing before winter sets in..LOL

          Comment


          • #6
            Not a symptom of Sticky valve. take the top cover off the carb and pull the slide out. make sure the 2 holes in the bottom of the slide are open, When you remove the slide you will see a couple ports in the carb body under the slide spray carb cleaner thru those ports to make sure they are free and not plugged. Reassemble making sure the rubber diaphragm has no holes in it and is properly in place and see if it works. There is not really much to that part of the carb. The rear vent tube does not plug into the carb at all. From the factory it plugged into the back of the air cleaner housing but most have removed it from there and run it down and under the bike with a small filter on the hose. If it is run to your carb remove it it don't go there.

            Comment


            • #7
              Originally posted by Roadtalker View Post
              the venturi slide never moves, and the rear cyclinder vent tube plugged into the cv port makes no difference in the lack of movement, unplugged either.
              are there two vacuum ports for the slide?
              The black pvc looking thing with 8mm vacuum hose is the vent for the slide, push the slide with a finger it should go up easily a drop fairly quickly when released, it could be scorched from intake backfires ( coughs) #0000 steel wool will polish it nicely

              Comment

              Latest Posts

              Collapse

              Topics Statistics Last Post
              Started by Roadie, 2 hours ago
              5 responses
              32 views
              0 likes
              Last Post Shores
              by Shores
               
              Started by reddog3979, 08-27-2018, 08:04 AM
              23 responses
              454 views
              0 likes
              Last Post Duke
              by Duke
               
              Started by Boatmark, 1 day ago
              12 responses
              153 views
              0 likes
              Last Post Duke
              by Duke
               
              Started by roadiemort, 1 day ago
              1 response
              102 views
              0 likes
              Last Post roadiemort  
              Started by roadiemort, 08-22-2020, 04:09 AM
              279 responses
              1,643 views
              1 like
              Last Post BigPainRing  
              Started by roadiemort, 1 day ago
              0 responses
              50 views
              0 likes
              Last Post roadiemort  
              Started by Father Pobasturd, 05-22-2019, 06:24 PM
              27 responses
              405 views
              0 likes
              Last Post roadiemort  
              Started by davej, 2 days ago
              2 responses
              83 views
              0 likes
              Last Post davej
              by davej
               
              Started by Michael72, 09-02-2020, 11:48 AM
              16 responses
              342 views
              0 likes
              Last Post Tropicalrs  
              Started by Lug Nut, 3 days ago
              3 responses
              82 views
              0 likes
              Last Post Lug Nut
              by Lug Nut
               
              Started by Slammed&Cammed, 1 week ago
              14 responses
              263 views
              1 like
              Last Post D-Fresh
              by D-Fresh
               
              Started by Father Pobasturd, 6 days ago
              15 responses
              251 views
              0 likes
              Last Post D-Fresh
              by D-Fresh
               
              Started by brianmac, 1 week ago
              67 responses
              699 views
              0 likes
              Last Post brianmac  
              Started by Doc_V, 4 days ago
              8 responses
              115 views
              0 likes
              Last Post Doc_V
              by Doc_V
               
              Started by Bip_Bip, 6 days ago
              32 responses
              274 views
              0 likes
              Last Post Bip_Bip
              by Bip_Bip
               
              Started by Father Pobasturd, 1 week ago
              6 responses
              93 views
              0 likes
              Last Post MikeyC
              by MikeyC
               
              Started by Lifeguard, 02-16-2019, 09:07 PM
              28 responses
              460 views
              2 likes
              Last Post Duke
              by Duke
               
              Started by brianmac, 11-06-2018, 08:57 AM
              101 responses
              2,646 views
              0 likes
              Last Post brianmac  
              Started by roadiemort, 6 days ago
              6 responses
              119 views
              0 likes
              Last Post roadiemort  
              Started by Darkkill57, 5 days ago
              5 responses
              150 views
              0 likes
              Last Post brianmac  
              Working...
              X